Search results

Be careful. The AX15 was always a 23 spline output. It was first used in late 1989 and 1990 behind the 4.2. The only major change in 1991 was to change the motor to a 4.0. The NP231 came on the Wrangler 6 cylinder in 1988 with a 21 spline input and changed to the 23 spline when they started...

Are there 2 lines from the outlet side of the fuel filter? The center one should go to the carb. The one on the edge of the fuel filter should go to a line back to the gas tank I think. Not sure what it is, but I've heard there could be problems if it isn't there. Otherwise, I would still...

I'm assuming you don't have an electric fuel pump. I put a new pump on my 87 when I did a motor rebuild. It did the same thing as yours. The new pump was bad. I've also seen one with a fuel pressure regulator that didn't allow enough volume of gas to pass to run at higher rpms. It worked fine at...

I've always heard you use WD40 to free up parts and things like that, but that it was too corrosive itself too use as a protectant.

Thanks Break. But I was just responding to the second half of the JeepPunk's 2nd post.

<I also have a problem with my signal lights. My emergency lights work but not my signals is that a burnt fuse> Look for the flasher relay. It should be on the fuse panel and round. There will probably be 2 of them. One is for the emergency flashers and one is for the turn signals. On my 87...

RE: Marvel Mystery Oil I'm not disputing you Bounty, but isn't the clocking difference on the transmission instead of the transfer case? That's what I've been told, but haven't verified it myself.

RE: T-case swap. I heard the 2150 is an altitude compensated version of the 2100. Not sure exactly what the difference is though.

According to Advance Adapters, the 999 and 904 automatics from 87 to 2002 used a flush 23 spline input. The AW4 used a flush 21 spline. So I guess it depends on what 2 automatics you have. The bolt pattern should be ok as long as your spline count is good. And I would agree with YJDave. Look at...

RE: Stereo question I'm not sure abot the side windows. I know the back glass is different. My buddy's CJ is fiberglass like my YJ though.

RE: Differential Whining? I might have got lucky for once. Just won an 89 wrangler ax15, bell housing, and shifter on ebay for about a hundred bucks plus shipping. Now to find a 231 tcase, rebuild new transmission, and ditch the Peugeot.

RE: attn: 90xjay Does anyone know if an ax15 from a Comanche will fit a wrangler? I'm just trying to find out what all I can find a donor transmission in. I know a Cherokee transmission has to have the tcase mount holes redrilled to get the front drive line angle. Found a write-up on that. I...

I agree. A boat has an alternator, but you don't take the boat on a trip every day to work or play. I wish I could though. Just for the info of those who disagree, I got this advice from an Interstate battery distributor. He could have made more selling me the deep cycle battery, but he was...

Deep cycle batteries are made to be charged and then removed from the charger. Trickle charging is ok, but the charging system of a vehicle will greatly shorten the life of it. It will work, but you will probably have to replace it within a year.

If it has the plastic valve cover, replace it with an aluminum one before setting the motor. The back screw is a bear to get to. Also, I lowered the motor a little below the motor mounts to get the top 2 transmission bolts in. No knuckles busted there. Then I raised it back up and inserted the...

I had never done one myself until last year. I didn't use any manuals other than a Haynes to get the right torques for the bolts. Otherwise, I would just remove a bolt and put it in a bag with a note explaining where it came from. I tagged all wires and hoses with a piece of tape and a note as...

Redlineweber is about the best site I've found too. If your choke isn't closing at all, it could be linkage binding or it could be the coil is either bad or not adjusted right. There are 3 screws on the outside of the choke coil housing. Loosen them and turn the plastic housing while looking in...

Is it not opening or not closing? The keyed power is to open it up as it warms up. I had to adjust mine several times to find a good setting. It was kind of finicky about where it was set.

I would bet on the sending unit too. I'm on my third one.

RE: Florida Jeepers Look at the Tcase tag like n0madic said. Also, look at the transmission body. If it's bolted together lengthwise, it's the Peugeot. Unless the previous owner swapped in a newer transmission, that's what you have anyway no matter which year it is. That also makes the Tcase a...